Environmental impacts associated with the production, use, and end-of-life of a woollen garment

ingridha on 25. May 2020

S.G. Wiedemann, L. Biggs, B. Nebel, K. Bauch, K. Laitala, I.G. Klepp, P.G. Swan and K. Watson.

Abstract

Purpose

The textiles industry is a substantial contributor to environmental impacts through the production, processing, use, and end-of-life of garments. Wool is a high value, natural, and renewable fibre that is used to produce a wide range of garments, from active leisure wear to formal wear, and represents a small segment of the global fashion industry. Woollen garments are produced by long, global value chains extending from the production of ‘greasy’ wool on sheep farms, through processing to garment make-up, retail, consumer use, and end-of-life. To date, there have been limited life cycle assessment (LCA) studies on the environmental impacts of the full supply chain or use phase of garments, with the majority of wool LCA studies focusing on a segment of the supply chain. This study aimed to address this knowledge gap via a cradle-to-grave LCA of a woollen garment.

Methods

This study investigated greenhouse gas (GHG) emissions, fossil fuel energy, and water stress associated with the production, use, and end-of-life of a lightweight woollen sweater (300-g wool), together with inventory results for freshwater consumption and land occupation. Primary datasets were used for the wool production and wool processing stages, while primary datasets relating to consumer garment use were supplemented with literature data. Impacts were calculated and reported per garment wear event.

Results and discussion

Impacts per wear were 0.17 (± 0.02) kg CO2-e GHG, 0.88 (± 0.18) MJ fossil energy, and 0.96 (± 0.42) H2O-e water stress. Fossil fuel energy was dominated by wool processing, with substantial contributions of energy also arising from retail and garment care. Greenhouse gas emissions from wool production (farming) contributed the highest proportion of impacts, followed by lower contributions from processing and garment care. Contributions to water stress varied less across the supply chain, with major contributions arising from production, processing, and garment use.

Conclusions

Opportunities to improve the efficiency of production, processing, and garment care exist, which could also reduce resource use and impacts from wool. However, the number of garment wear events and length of garment lifetime was found to be the most influential factor in determining garment impacts. This indicated that consumers have the largest capacity to influence the sustainability of their woollen garments by maximising the active garment lifespan which will reduce overall impacts.

Click here to read the full article (springer.com).

KRUS final report: Enhancing local value chains in Norway

ingridha on 9. September 2019

Ingun Grimstad Klepp, Tone Skårdal Tobiasson, Vilde Haugrønning, Gunnar Vittersø, Lise Grøva, Torhild Kvingedal, Ingvild Espelien & Elin Kubberød

From its initiation in 2015 to the end in 2019, KRUS had two goals: to improve the market for and the value of Norwegian wool, and survey the opportunities for local production in a move towards a goal of sustainability in the fashion sector. On a larger scale, KRUS has looked at how we can re-establish an understanding of the connection between the raw material and the finished product within the textile industry and among consumers. It is critical to understand this connection, both to ensure quality products and to reach the market potential for Norwegian wool.

To restore the understanding of “where clothes come from” is also at the heart of challenges currently facing the textile industry. The consumption and production of textiles faces major challenges and changes in the future. Today the industry is characterized by low control and little knowledge, while growth in quantity, environmental impact, as well as stress on animals and humans is high. KRUS has contributed to the debate on sustainable clothing by focusing on local value-chains and locally produced apparel.

The focus on Norwegian wool and the specific qualities of the different breeds has played an essential role for Norwegian textile tradition and dress culture, and a better understanding of this has been essential to the project. An important challenge for Norwegian wool is that it has not been marketed with any kind of label of origin. Private actors have thus entered the field and developed their own private labels for Norwegian wool. In addition, there are few products on the market containing Norwegian wool beyond hand-knitting yarn, which means that availability has been limited.

Throughout the project, we have seen a shift, especially for older sheep breeds, which have posed a special challenge. Their wool is central in keeping Norwegian handicrafts alive, but the quality on some of the wool types has been declining. For others, the challenge is that much of the wool is not taken care of, and constitutes a waste problem. Through breeding-projects, work collaboration, looking closely at labelling systems and business models, KRUS has addressed these challenges.

Click here to read the full report (oda.oslomet.no)

Nisseluelandet—The Impact of Local Clothes for the Survival of a Textile Industry in Norway

ingridha on 22. June 2018

Ingun Grimstad Klepp & Kirsi Laitala

Abstract

The article discusses the importance of local clothing for the survival of the Norwegian textile industry. It draws upon stakeholder interviews, as well as desktop research. Local clothes are discussed as they are understood by consumers, as knitted sweaters, bunads (Norwegian national costumes), and home-made clothing. The review shows how these products, and especially the materials used in their production, have been crucial for the continued existence of the Norwegian textile industry. We argue that the concept “local clothes” can contribute to showcasing resources outside the global “fast fashion” manufacturing system.

Click here to read the full article (tandfonline.com)

Use phase of apparel: A Literature review for Life Cycle Assessment with focus on wool.

ingridha on 24. February 2018

Kirsi Laitala, Ingun Grimstad Klepp & Beverley Henry

Summary

This report presents a literature review of clothing use phase. The purpose is to support improved methodological development for accounting for the use phase in Life Cycle Assessment (LCA) of apparel. All relevant textile fibres are included in the review. However, the main focus is on wool. We ask whether the use of wool has different environmental impacts than clothes in other fibres. The report builds on a review of literature from the past 20 years. The review showed that clothing made from different materials are used, and reused in different ways. Wool is washed differently as it has about ten degrees lower washing temperature than the average laundry in Europe. Wool is also more likely to be either dry-cleaned or washed by hand than other textiles. Moreover, when dried, it is less likely to be tumble-dried.

When comparing the number of days between the washes of different types of clothes, we found that respondents were likely to use their woollen products about twice as long between washes compared to their equivalent cotton products. We also found that woollen products had a longer average lifespan and were more likely to be reused or recycled. There is a lot of research-based information available concerning the use and re-use of clothing, and we believe there are sufficient results available on which to base LCA studies. Furthermore, we believe that environmental tools that compare different fibres but exclude use phase provide misleading results. Including the use phase in fibre ranking benchmark tools will improve the rigour and accuracy of these tools for all fibres, compared to reporting results for fibre production only. However, we have also shown that there are several methodological, conceptual and empirical knowledge gaps in existing literature.

Click here to read the full report (researchgate.net)

Global laundering practices: Alternatives to machine washing

ingridha on 15. October 2017

Kirsi Laitala, Ingun Grimstad Klepp & Beverly Henry

Abstract

This article discusses laundering practices around the world including alternative methods such as washing by hand, airing, steaming, and dry-cleaning. These methods, which have received little attention in research, are often more suited to products made of wool, silk or other materials able to be cleaned using gentler techniques than more commonly used fibers such as cotton and synthetics. The material is based on extensive literature review from the past 20 years and reanalysis of previously unpublished survey data. The results show that washing by hand is common and that is the main laundering method in most rural areas of developing countries, but also significant for smaller portion of laundry in developed countries. Dry cleaning is less common, and mainly used for specific clothing items. Simple method such as airing can reduce the washing frequency, and thus reduce the environmental impacts resulting from the cleaning of clothes.

Click here to read the full article (oda.oslomet.no)

Wool you wear it? – woollen garments in Norway and the United Kingdom

ingridha on 24. August 2016

Marie Hebrok, Ingun G. Klepp & Joanne Turney

Abstract

This article was developed from the project ‘Valuing Norwegian Wool’ initiated by the Norwegian National Institute for Consumer Research to generate knowledge on how wool can contribute to sustainable textile consumption, and how value creation can be increased in the Norwegian wool industry. The article will compare consumer perceptions, attitudes, practices and knowledge concerning wool as a material and as garments in Norway and in the United Kingdom, through a case study of wardrobes owned by six middle-class families.

The aim is to generate knowledge about the diverse web of aspects that influence consumption of woollen garments. The wardrobe study as a method aims to include the materiality of garments in clothes research in a more direct way. Analysing the materiality in connection with the social and cultural aspects of clothes gives us a better understanding of the relations between materiality and practice.

Click here to read the full article (southampton.ac.uk)

Why Cotton as Linen? The Use of Wool in Beds in Norway

ingridha on 22. August 2016

Ingun Grimstad Klepp, Tone Skårdal Tobiasson & Kirsi Laitala

Abstract

Cotton is the “natural” choice and the dominating material in bed linen and sleepwear in Norway as in many other European countries. Regulation of temperature and humidity are important for good sleep, but they are not cotton’s strong points. There must have been other than the functional reasons which made cotton the winner in the bedding market. This article builds on literature about bedding in Norway from the 1800s and survey questions from 1951. We ask the question: what materials have been used and why? Wool was used in all bed textiles, both closest to the body and the layers over and under, from the cheapest chopped rags to the most costly textiles. The decline was seen throughout the 1800 and 1900s, but only in the 1960s does wool become totally absent as a next to skin bed textile. The cheap imports of cotton made cottage industry and home production unprofitable and the new emphasis on cleanliness gave cotton a clear leverage.

Click here to read the full article (tandfonline.com)

Valuing Norwegian Wool

ingridha on 24. October 2012

Marie Hebrok, Ingun Grimstad Klepp, Tone S. Tobiasson, Kirsi Laitala, Marit Vestvik & Madeline Buck

Summary

Wool has been called the white gold and has warmed and brought joy to the Norwegian population throughout history. It is also a textile fibre with many unused features. The starting point of the project Valuing Norwegian Wool is a desire to help Norwegian agriculture, wool based industry, and design to exploit the potential inherent in Norwegian wool as raw material, and in the Norwegian textile tradition. Norway has a thriving textile industry and several strong companies that produce products made of wool. The marketing of the origin of the raw material these products are produced from is however rather inadequate and sometimes misleading. While fewer and fewer of the products are made of Norwegian wool, consumers – not without reason – take it for granted that Norwegian producers use Norwegian wool.

The project is funded by the Norwegian Research Council and led by SIFO. The project partners include representatives from the entire value chain – from agricultural organizations, industry and commerce, and design and consumption. This report is one of many publications in the project and makes visible the challenges that exist in the value chain, but also the great potential that is there.

Click here to read the full report (oda.oslomet.no)